Skip to main content Skip to office menu Skip to footer
Capital IconMinnesota Legislature

Good practices

Published (2/3/2012)
By Sue Hegarty
Share on: 



Rep. Chris Swedzinski, center, listens Jan. 26 during testimony about his bill that would authorize the Department of Agriculture to inspect feed operations and to issue Good Manufacturing Practices certificates. Seated with him is Matt Frederking, director of regulatory affairs and operations for Ralco Nutrition in Marshall. (Photo by Paul Battaglia)Somewhere in Brazil there is a piglet who has been squealing for her Minnesota swill.

This little piggy is caught up in international export red tape because the federal Food and Drug Administration has temporarily stopped issuing Good Manufacturing Practices certificates for commercial feed operations. Brazil and the Dominican Republic require the certificates from U.S. Sfeed manufacturers before they’ll accept commercial feed exports. Other countries may soon follow suit.

Frustrated Minnesota suppliers with feed export deals are crying “wee, wee, wee” at home.

“We had the country of Brazil back in 2010 put in place barriers for us to be able to import our products, and one of those was getting a certificate of Good Manufacturing Practices from a state or federal agency,” said Matt Frederking, director of regulatory affairs and operations for Ralco Nutrition in Marshall.

“A lot of the products we move into the global marketplace are non-medicated feed additives, and so at the federal level prior to 2011, they would issue these documents.”

But with passage of the federal Food Safety Modernization Act of 2011, the issuance of GMP certifications stopped until new stricter rules can be adopted. The Minnesota Department of Agriculture has never had to inspect and issue a GMP certificate for non-medicated feed before, so there are no rules at the local level either.

As the FDA goes through the process of writing the new federal rules, manufacturers of non-medicated feed are losing patience and money.

Some states are scurrying to pass their own rules to authorize the issuance of state GMP certificates. Kansas is the only state that has started issuing GMP certificates.

Doug Lueders, MDA supervisor for the commercial feed regulatory program, estimates conducting the necessary inspections could take between 20 and 40 hours per facility, depending upon the compliance level of each feed facility. The projected cost of the inspection/certification is $50 per hour, plus mileage.

“If we can open up these export markets, (the fee) is not a concern for us from an industry perspective,” Frederking said.

HF1926 would speed that process along in Minnesota by authorizing the MDA to inspect operations and to issue the certificates. The House Agriculture and Rural Development Policy and Finance Committee approved the bill Jan. 31 and referred it to the House Government Operations and Elections Committee. A companion, SF1527, sponsored by Sen. Gary Dahms (R-Redwood Falls), awaits action by the Senate State Government Innovation and Veterans Committee.

Minnesota annually exports $4.8 million of feed to Brazil and $85,000 to the Dominican Republic, according to Su Ye, market research program director for MDA. Though the numbers pale in comparison to Minnesota’s total agricultural exports to the world at $5 billion a year, it was significant enough for Ralco Nutrition to seek a statewide pre-emptive rule, ahead of the FDA.

“It’s kind of a temporary fix bill to get rules in place in Minnesota for certification for GMPs,” said Rep. Chris Swedzinski (R-Ghent), the bill’s sponsor.

The intent is to authorize the state to do inspections at the manufacturer’s request so they can earn the certificate and resume exporting. Once the FDA adopts its new rules, the Minnesota legislation would sunset and the MDA would automatically adopt the FDA rules.

Lueders estimates that inspections could begin within 30 to 60 days of enactment.

The Minnesota Agri-Growth Council represents some of the nation’s largest commercial feed manufacturers, such as Cargill, CHS and Land O’Lakes.

“We’re supportive of (the bill),” said President Daryn McBeth.

However, McBeth said some manufacturers have been able to skirt the export requirement by showing certification from another state or because they hold a federal Hazard Analysis & Critical Control Points certificate. HACCP is a different federal food safety management system but there’s no guarantee that other countries will allow substitution of one certificate for the other.

“The importing country is at the controls here. It’s not up to us to dictate what the importing country is looking for,” Lueders said, adding that Mexico has also adopted the GMP certification requirement but is not enforcing it.

Session Weekly More...


Session Weekly Home



Related Stories


From soils to consumption
Ag law helps gardeners determine what plants are suitable for state climate
(view full story) Published 5/25/2012

A green thumbs up
Ag policies seek to protect garden and landscape consumers
(view full story) Published 4/6/2012

Minnesota Index: A bushel and a peck
Facts and statistics on farming in Minnesota
(view full story) Published 2/24/2012

Good practices
Feed manufacturers ask for stopgap to forthcoming FDA rules
(view full story) Published 2/3/2012

More food inspectors
Direct sales food retailers may need handler license in some instances
(view full story) Published 4/1/2011

Minnesota Index: A Minnesota Breakfast
Facts and statistics on Minnesota's homegrown foods
(view full story) Published 3/25/2011

Learning about what you eat
Students use ‘exploding cheeseburger’ to teach agriculture
(view full story) Published 2/25/2011

At Issue: Repeal of Green Acres
The issue: ‘A farm is a farm is a farm’
(view full story) Published 2/4/2011